Product ID:MAC'S STARTING FLUID
MSDS Date:02/10/1995
FSC:9150
NIIN:00N080126
MSDS Number: CFPXK

VALVOLINE INC

LEXINGTON, KY 40512
US

Emergency Phone: 800-274-5263

Info Phone: 606-264-7000

Cage: GO029

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

HEPTANE

CAS: 142-82-5

RTECS: MI7700000

Fraction By Weight: 67-77%

OSHA PEL 500 PPM

ACGIH TLV: 400 PPM; 500 STEL

ETHANE, 1,1'-OXYBIS-; (ETHYL ETHER) (CERCLA)

CAS: 60-29-7

RTECS: KI5775000

Fraction By Weight: 10-20%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM; 500 STEL

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

CARBON DIOXIDE

CAS: 124-38-9

RTECS: FF6400000

Fraction By Weight: 4.8-15%

OSHA PEL 5000 PPM

ACGIH TLV: 5000 PPM; 30000 STEL

HEXANE (CERCLA)

CAS: 110-54-3

RTECS: MN9275000

Fraction By Weight: 2.7%

OSHA PEL 500 PPM

ACGIH TLV: 50 PPM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

IF POSSIBLE, DO NOT LEAVE UNATTENDED.

RTECS: 9999999ZZ

SEEK IMMED MED ATTN; KEEP PERSON WARM & QUIET. IF

RTECS: 9999999ZZ

ADMINISTER OXYGEN.

RTECS: 9999999ZZ

(CONSULT YOUR INDUSTRIAL HYGIENIST). ENGINEERING

RTECS: 9999999ZZ

TRACT) (PRE-EXISTING LUNG DISORDERS, E.G.

RTECS: 9999999ZZ

CNS DEPRESSION (DIZZINESS, DROWSINESS, WEAKNESS,

RTECS: 9999999ZZ

ELIMINATE ALL IGNITION SOURCES (FLARES, FLAMES,

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE: EXPOS CAUSES EYE IRRIT. SYMPS MAY
INCL STINGING, TEARING, REDNESS, & SWELLING. ADDNL SYMPS OF EYE
EXPOS MAY INCL: BLURRED VISION. SKIN: EXPOS MAY CAUSE MILD IRRIT.
PRLNGD/RPTD EXPOS MAY DRY SKIN. SYMPS MAY INCL REDNESS, BURNING,
DRYING & CRACKING, & SKIN BURNS. INGEST: SINGLE DOSE ORAL TOXICITY
IS LOW. (SUPDAT)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:TARGET ORGAN EFTS: PRLNGD & RPTD INHAL OF HIGH
LEVS OF MIXED ISOMERS OF HEXANE RESULTED IN KIDNEY DMG IN MALE
RATS. EFTS OBSERVED ARE SAME AS THOSE SEEN IN MALE RATS EXPOS TO
OTHER HYDROCARBONS. MECHA NISM BY WHICH THESE CHEMS CAUSE
CHARACTKIDNEY TOX IS UNIQUE TO MALE RAT & KIDNEY EFTS ARE NOT
EXPECTED TO OCCUR IN MAN.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS MATERIAL. PRE-EXISTING LUNG
DISORDERS, EG ASTHMA-LIKE CONDITIONS MAY BE AGGRAVATED BY EXPOSURE
TO THIS MATERIAL.

First Aid:EYE: IMMED MOVE INDIV AWAY FROM EXPOSURE & INTO FRESH AIR.
FLUSH GENTLY W/WATER FOR AT LST 15 MINS WHILE HOLDING EYELIDS
APART; SEEK IMMED MED ATTN. SKIN: REMOVE CONTAMD CLTHG. WASH EXPOS
AREA W/SOAP & WATER. IF SYMPS PERSIST, SEEK MED ATTN. LAUNDER
CLTHG BEFORE REUSE. INGEST: DO NOT INDUCE VOMIT. MATL IS ASPIR HAZ.
IF PERS IS DROWSY/UNCON, PLACE ON LEFT SIDE W/HEAD DOWN. SEEK MED
ATTN. (ING 5)

Lower Limits:1%
Extinguishing Media:REGULAR FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . APPROPRIATE TURN OUT GEAR AND CHEMICAL RESISTANT
PERSONAL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR DRUM (EVEN EMPTY) BECAUSE PRODUCT (EVEN JUST RESIDUE) CAN
IGNITE EXPLOSIVELY.

Spill Release Procedures:SMALL SPILL: ALLOW TO EVAP. ELIM ALL SOURCES
OF IGNIT SUCH AS FLARES, FLAMES (INCL PILOT LIGHTS), & ELEC SPARKS.
VENT AREA. LARGE SPILL: ALLOW TO EVAP. PERSONS NOT WEARING PROT
EQUIP SHOULD BE EXCLUDE D FROM AREA UNTIL LEAK HAS BEEN REPAIRED.
(ING 11)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CNTNRS OF MATL MAY BE HAZ WHEN
EMPTIED. SINCE EMPTIED CNTNRS RETAIN PROD RESIDUES (VAPOR, LIQUID,
AND/OR SOLID), ALL HAZ PRECS GIVEN MUST BE OBSERVED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:IF WORKPLACE EXPOSURE LIMIT(S) OF PROD OR ANY
COMPONENT IS EXCEEDED, NIOSH APPRVD AIR SUPP RESP IS ADVISED IN
ABSENCE OF PROPER ENVIRON CNTRL. OSHA REGS ALSO PERMIT OTHER NIOSH
APPRVD RESPS (NEG PRESS TYPE) UNDER SPECIFIED CNDTNS (ING 8)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HLTH HAZ: SWALLOWING SML AMTS DURING NORM HNDLG IS NOT LIKELY TO CAUSE
HARMFUL EFTS; SWALLOWING LRG AMTS MAY BE HARMFUL. MATL CAN ENTER
LUNGS DURING SWALLOWING/VOMIT & CAUSE LUNG INFLAMMATION &/OR DMG .
INHAL: EXPOS TO VAP/MIST IS POSS. SYMPS OF OVEREXP: GI IRRIT (NAUS,
VOMIT, DIARR), IRRIT (NOSE, THROAT, RESP (ING 9)

Boiling Pt:B.P. Text:94.0F,34.4C
Vapor Pres:439 @ 68F
Vapor Density:>1.000
Spec Gravity:0.773
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Appearance and Odor:CLEAR LIQUID, HOMOGENEOUS SOLUTION.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY FORM: CARBON DIOXIDE AND CARBON
MONOXIDE, VARIOUS HYDROCARBONS.

Waste Disposal Methods:VENTILATE AREA OF SPILL. ALLOW MATERIAL TO
EVAPORATE. DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS .

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.